Hi all,
I have a 2005 Seat Altea, 2.0 tdi sport. Use to be driven daily up to this time last year, and then even less once uk lockdown hit... Mainly sits in the drive now so condensation / cold may be playing a factor...
Over the last day + night the alarm in the car randomly goes off, nothing untoward, just unlock and re lock and alarm stops for a while.
Its getting worse occurring more frequently.
I took the car for a drive earlier in the day and noticed that none of the functions of the driver door (ie the elec windows + enable/disable passenger windows) + the lock and unlock button in the central console worked or lit up... A little while later they worked again, then stopped...
three things:
1) is there a way to disable the alarm? From what I have found there is a yellow turn lock on the passengers door - I did that, but alarm still went off a little while later. I took the main battery off and the alarm sounded as well.
2) I did a scan using vcds. Logs attached:
The key error is the door control module no signal/communication...
I'm guessing these two are linked, and that either I have a wiring or control unit problem?
Is there a way from VCDS to get the part number or can I look it up else where to order a replacement? (I'd rather open the door card once and check wiring and replace unit at the same time then open the door card to check wiring and then close it backup to order a unit if possible?)
3) Anyone got a guide for replacing the unit? Its the drivers door...
I have a 2005 Seat Altea, 2.0 tdi sport. Use to be driven daily up to this time last year, and then even less once uk lockdown hit... Mainly sits in the drive now so condensation / cold may be playing a factor...
Over the last day + night the alarm in the car randomly goes off, nothing untoward, just unlock and re lock and alarm stops for a while.
Its getting worse occurring more frequently.
I took the car for a drive earlier in the day and noticed that none of the functions of the driver door (ie the elec windows + enable/disable passenger windows) + the lock and unlock button in the central console worked or lit up... A little while later they worked again, then stopped...
three things:
1) is there a way to disable the alarm? From what I have found there is a yellow turn lock on the passengers door - I did that, but alarm still went off a little while later. I took the main battery off and the alarm sounded as well.
2) I did a scan using vcds. Logs attached:
Code:
(No subject)
Sunday,10,January,2021,19:17:36:38462
VCDS -- Windows Based VAG/VAS Emulator Running on Windows 8 x64
VCDS Version: 20.12.0.1 (x64)
Data version: 20201125 DS322.1
www.Ross-Tech.com
VIN:
Mileage: 237400km-147513mi Repair Order:
--------------------------------------------------------------------------------
--------------------------------------------------------------------------------
Chassis Type: 5P (1K0)
Scan: 01 03 08 09 15 16 17 19 25 42 44 46 52 56 62 72
VIN: VSSZZZ5P Mileage: 237400km-147513miles
00-Steering Angle Sensor -- Status: OK 0000
01-Engine -- Status: Malfunction 0010
03-ABS Brakes -- Status: OK 0000
08-Auto HVAC -- Status: Malfunction 0010
09-Cent. Elect. -- Status: Malfunction 0010
15-Airbags -- Status: OK 0000
16-Steering wheel -- Status: Malfunction 0010
17-Instruments -- Status: OK 0000
19-CAN Gateway -- Status: Malfunction 0010
25-Immobilizer -- Status: OK 0000
42-Door Elect, Driver -- Status: Sporadic communication error 1000
44-Steering Assist -- Status: Malfunction 0010
46-Central Conv. -- Status: Malfunction 0010
52-Door Elect, Pass. -- Status: OK 0000
56-Radio -- Status: OK 0000
62-Door, Rear Left -- Status: OK 0000
72-Door, Rear Right -- Status: OK 0000
-------------------------------------------------------------------------------
Address 01: Engine Labels: 03G-906-016-BKD.clb
Part No SW: 03G 906 016 HE HW: 028 101 229 1
Component: R4 2,0L EDC G000SG 7000
Revision: 12345678 Serial number: SEZ7Z0E3077378
Coding: 0050072
Shop #: WSC 06402 785 00200
VCID: 6DDACB067407C0ECD9-8038
1 Fault Found:
17058 - Cylinder 4 Glow Plug Circuit (Q13)
P0674 - 000 - Electrical Fault
Freeze Frame:
RPM: 840 /min
Torque: 48.0 Nm
Speed: 0.0 km/h
Load: 0.0 %
Voltage: 14.44 V
Bin. Bits: 00101100
Temperature: 13.5°C
Bin. Bits: 10110000
Readiness: 0 0 0 0 0
-------------------------------------------------------------------------------
Address 03: ABS Brakes Labels: 1K0-907-379-MK60-F.lbl
Part No SW: 1K0 907 379 Q HW: 1K0 907 379 Q
Component: ESP FRONT MK60 0102
Revision: 00T12001
Coding: 0006898
Shop #: WSC 06402 785 00200
VCID: 408442B21315FD8442-8014
No fault code found.
-------------------------------------------------------------------------------
Address 08: Auto HVAC Labels: 1K0-907-044.lbl
Part No: 5P0 907 044 B
Component: ClimatronicPQ35 006 0203
Shop #: WSC 00000 000 00000
VCID: 2F66110EBE8B72FCAB-807A
1 Fault Found:
00229 - Refrigerant Pressure
002 - Lower Limit Exceeded
-------------------------------------------------------------------------------
Address 09: Cent. Elect. Labels:. 3C0-937-049-23-H.lbl
Part No SW: 3C0 937 049 E HW: 3C0 937 049 E
Component: Bordnetz-SG H37 1002
Revision: 00H37000 Serial number: 00000003392571
Coding: 81880F2700041000001E00000100000000007F0B5C
Shop #: WSC 06402 785 00200
VCID: 2B5E051E8A930EDC87-807E
Subsystem 1 - Part No: 5P0 955 119 B Labels: 1KX-955-119.CLB
Component: Wischer SE359 012 0402
Coding: 00056272
Shop #: WSC 06402
1 Fault Found:
01331 - Door Control Module; Driver Side (J386)
004 - No Signal/Communication
Freeze Frame:
Fault Status: 01100100
Fault Priority: 2
Fault Frequency: 17
Reset counter: 75
Mileage: 237404 km
Time Indication: 0
Freeze Frame:
OFF
Voltage: 12.25 V
OFF
OFF
OFF
OFF
OFF
-------------------------------------------------------------------------------
Address 16: Steering wheel Labels: 1K0-953-549-MY8.lbl
Part No SW: 1K0 953 549 AG HW: 1K0 953 549 AG
Component: J0527 034 0070
Coding: 0002042
Shop #: WSC 06402 785 00200
VCID: 77F6E96E065B7A3C33-8022
Subsystem 1 - Part No: XXXXXXXXXXX
Component: E0221 004 0060
1 Fault Found:
00888 - Wiper Switch for Intermittent Operation (E22)
014 - Defective - Intermittent
-------------------------------------------------------------------------------
-------------------------------------------------------------------------------
Address 19: CAN Gateway Labels:. 1K0-907-530-V1.clb
Part No SW: 1K0 907 530 F HW: 1K0 907 951
Component: Gateway H10 0120
Revision: H10 Serial number: 28001056308A85
Coding: 3D3F0340078203
Shop #: WSC 06402 785 00200
VCID: 2A50001A856917D47C-807E
1 Fault Found:
01331 - Door Control Module; Driver Side (J386)
004 - No Signal/Communication - Intermittent
Freeze Frame:
Fault Status: 00100100
Fault Priority: 2
Fault Frequency: 10
Reset counter: 115
Mileage: 237404 km
Time Indication: 0
Date: 2000.00.00
Time: 14:47:00
-------------------------------------------------------------------------------
Address 25: Immobilizer Labels: 1K0-920-xxx-25.clb
Part No: 5P0 920 923 A
Component: IMMO VO3 0616
Shop #: WSC 01069 210 103434
VCID: 2F66110EBE8B72FCAB-807A
No fault code found.
-------------------------------------------------------------------------------
Address 42: Door Elect, Driver
Cannot be reached
-------------------------------------------------------------------------------
Address 44: Steering Assist Labels: 1Kx-909-144-G2V2.clb
Part No: 1K2 909 144 J
Component: EPS_ZFLS Kl.5 D04 1606
Shop #: WSC 00000 000 00000
VCID: 336E1D7E52A3561CCF-8066
1 Fault Found:
00778 - Steering Angle Sensor (G85)
000 - -
-------------------------------------------------------------------------------
Address 46: Central Conv. Labels:. 1K0-959-433-MIN.clb
Part No: 1K0 959 433 AK
Component: KSG 0401
Coding: 19C000DC2D0005054C5F863000CC
Shop #: WSC 01069 210 174572
VCID: 79F2EF56304F6C4C45-802C
Subsystem 5 - Part No: 5P0 951 171 C
Component: Innenraumueberw.009 4865
Coding: 00000000
Shop #: WSC 00000
Subsystem 6 - Part No: 1K0 951 605 C
Component: LIN BACKUP HORN H03 1301
Subsystem 7 - Component: NGS n.mounted
1 Fault Found:
01331 - Door Control Module; Driver Side (J386)
004 - No Signal/Communication
-------------------------------------------------------------------------------
Address 52: Door Elect, Pass. Labels: 1K0-959-702-MAX2.lbl
Part No: 1T0 959 702 C
Component: Tuer-SG 024 2432
Coding: 0000656
Shop #: WSC 06402 785 00200
VCID: 38742A524BC5B544FA-806C
No fault code found.
-------------------------------------------------------------------------------
Address 62: Door, Rear Left Labels: 1K0-959-703-GEN2.lbl
Part No: 1K0 959 703 E
Component: Tuer-SG 021 2426
Coding: 0000144
Shop #: WSC 06402 785 00200
VCID: 3260187AADB95F14C4-8066
No fault code found.
-------------------------------------------------------------------------------
Address 72: Door, Rear Right Labels: 1K0-959-704-GEN2.lbl
Part No: 1K0 959 704 E
Component: Tuer-SG 021 2426
Coding: 0000144
Shop #: WSC 06402 785 00200
VCID: 336E1D7E52A3561CCF-8066
No fault code found.
End
The key error is the door control module no signal/communication...
I'm guessing these two are linked, and that either I have a wiring or control unit problem?
Is there a way from VCDS to get the part number or can I look it up else where to order a replacement? (I'd rather open the door card once and check wiring and replace unit at the same time then open the door card to check wiring and then close it backup to order a unit if possible?)
3) Anyone got a guide for replacing the unit? Its the drivers door...